裝載機蓄電池使用注意事項

裝載機蓄電池一直是裝載機不可少的組成部分，通過蓄電池可以為車載用電設備供電，驅動啟動馬達，帶動發動機啟動等重要作用。那么裝載機蓄電池使用時應該注意哪些問題呢？

1、裝載機蓄電池的加液孔蓋上一般都會設計有通氣孔，在平時的使用過程中應經常檢查這些通氣孔，并始終保證其暢通。如果通氣孔不暢通的話，在進行充放電過程時，因蓄電池內發生的化學反應所產生的氣體無法及時排出，就會導致蓄電池鼓爆，引起蓄電池內部結構損壞，從而造成不必要的損失。
Dosing hole Shandong loaders batteries usually designed with a vent cover, in the usual course should always check the vent, and always ensure their smooth. If the vent is not blocked, then,during the charge and discharge process, the gas due to chemical reaction occurring within the battery can not be discharged generated, it will lead to a battery explosion drum, causing damage to the internal structure of the battery, resulting in unnecessary losses.

2、裝載機蓄電池的極柱要保持清潔，供電線路連接要牢固，要及時除去極柱和連接線頭處的氧化物。筆者在文章開頭就說了，如果連接不牢固或者因銹蝕造成極柱與接線接觸不良，就會對充電造成到很大的影響，使用起來也會降低蓄電池的使用壽命。
Shandong loader battery pole to keep clean, power lines connected to a solid, to promptly remove the oxide pole and connecting thread at. I said at the beginning of the article, if the connection is not secure or due to corrosion caused by the pole and wiring is bad, it will cause the charge to a great impact, using them will reduce battery life.

3、裝載機要防止蓄電池短路。在此需要特別注意，金屬器件一定不能放在蓄電池上，如鉗子、扳手、改錐等這些常用的金屬工具，因為金屬器件與蓄電池極柱連接并與金屬機身搭鐵后，會形成一個閉合回路，造成蓄電池短路，從而燒壞蓄電池，導致蓄電池報廢。另外，蓄電池上如果有污水或者臟物也應該及時清除，因為這些雜物也會導致蓄電池短路，使蓄電池發生損壞。
Shandong loader to prevent battery short circuit. Require special attention in this, the device must not be placed on metal batteries, such as pliers, wrenches, screwdrivers and other tools commonly used metals such as metal device is connected to the battery pole and rear metal body grounding, will form a closed loop , resulting in a battery short circuit, which burn batteries, lead battery scrap. In addition, if there is water on the battery or dirt should be promptly removed, because the debris will cause a short circuit the battery, so that the battery is damaged.

4、裝載機蓄電池應該定期檢查電解液是否充足。蓄電池電解液不足會使極板硫化，蓄電池容量降低。另外極板硫化的另一個重要原因就是蓄電池存電不足，存電不足還會造成蓄電池電氣性能降低，縮短使用壽命。
Shandong loaders should regularly check the battery electrolyte is sufficient. Battery electrolyte deficiencies would plate curing, the battery capacity decreases. In addition, another important reason is that the battery plate curing to save electricity, save electricity shortage will result in reduced battery electrical performance and shorten life.

5、裝載機蓄電池的日常保養。蓄電池如果超過一周以上的時間不用，應考慮對蓄電池進行斷電，如果蓄電池有開關，則應該斷開蓄電池開關。蓄電池如果長期不用，應將電解液調整到標準刻度線位置，并對蓄電池電量充滿。
Shandong loader routine maintenance batteries. Battery time if not more than a week, you should consider the battery to power, if the battery has a switch, you should disconnect the battery switch. If the long-term without the battery, the electrolyte should be adjusted to the standard position of the mark, and the battery is fully charged.